Question: A mechanical press is powered by a 30-hp motor and operates at 40 strokes per minute. It uses a flywheel, so that the rotational speed

A mechanical press is powered by a 30-hp motor and operates at 40 strokes per minute. It uses a flywheel, so that the rotational speed of the crankshaft does not vary appreciably during the stroke. If the strike length is 6 in., what is the maximum contact force that can be exerted over the entire stroke length? To what height can a 5052-O aluminum cylinder with a diameter of 0.5 in. and a height of 2 in. be forged before the press stalls?

Step by Step Solution

★★★★★

3.41 Rating (170 Votes )

There are 3 Steps involved in it

1 Expert Approved Answer

Step: 1 Unlock

Here power is equal to 30 hp which is equal to 198000 Ibs Assuming press stroke is moving with con... View full answer

Question Has Been Solved by an Expert!

Get step-by-step solutions from verified subject matter experts

Step: 2 Unlock

Step: 3 Unlock

Document Format (1 attachment)

972-E-M-E-B-D (553).docx

120 KBs Word File

Students Have Also Explored These Related Mechanical Engineering Questions!

A fan is powered by a 0.5-hp motor and delivers air at a rate of 85 m3/min determine the highest value for the average velocity of air mobilized by the fan. Take the density of air to be 1.18 kg/m3.

The pump of a water distribution system is powered by a 15-kW electric motor whose efficiency is 90 percent. The water flow rate through the pump is 50 L/s. The diameters of the inlet and outlet...

A 90-hp (shaft output) electric car is powered by an electric motor mounted in the engine compartment. If the motor has an average efficiency of 91 percent, determine the rate of heat supply by the...

Research the answers well Energy transfers by heat through the exterior walls and roof of a house at a rate of5.00103J/s=5.00kW5.00103J/s=5.00kWwhen the interior temperature is22.0C22.0Cand the...

Here is the case to analyse: Rivian Automotive, Inc. "The change over the next two decades from non-connected, combustion-powered vehicles to electric, con- nected, and increasingly autonomous...

roasting pans, canning pots, and camping gear. The products are with a proprietary protective coating. Their products are all forn sheet steel and fabricating them into the final product form bef One...

I want help ONLY with the selection of electro motor,what is the suitable motor for this design and why? The electro motors can be selected from Bosch and Mavilor Catalogues...

Old MathJax webview Please assist urgently Some of the tasks are described as press operations. These use a simple mechanical press that applies sufficient force for simple bending, riveting or force...

Suppose that x has a distribution with= 12 and= 4. If a random sample is taken of size n = 36, findstd dev. xbar. 12.00 0.67 2.00 0.11 4.00 The heights of 18-year-old men are approximately normally...

1. Lets pretend in its effort to control inflation, the Federal Reserve raises the federal funds target to a jaw-dropping 13%. This has caused a ripple effect on all other interest rates in the...

For each of the following scenarios, indicate whether a long-term asset has been impaired (Y for yes and N for no) and, if so, the amount of the loss that should berecorded. Book Value Estimated F...

Question 3 2 2 pts You followed Charlotta's story in documentary, Orgasm, Inc. What did she finally conclude, after having a spine procedure that was meant to produce orgasms? That the spinal...

Fiscally Troubled States Today. A number of major states, for example California, have been experiencing fiscal problems. Although no states have defaulted on their debts in recent years, a number of...

This problem illustrates that the factor of safety for a machine element depends on the particular point selected for analysis. Here you are to compute factors of safety, based upon the...

Find the current Ix in the 4-ohm resistor in the circuit shown. 12 3 6 4 2A

Determine the voltage Vo in the circuit shown. 12V 4 4 4 V. 2 2I

Dantell Ltd is developing a new clothes dryer, Dry Master, that it plans to sell to coin-operated laundries. Currently, the market leader is a product called Lacy, which is sold by a competitor. The...

Let X1, ... , Xn~Poi(1). (a) Find the best CR for testing Ho: 1 = 2 and Ha: 1 = 5 Ans: 241=1 (X1) e3n S k 5 n In k - 3n i=1 In UIN Etz1(x;) 2 c since In is negative . (b) If n = 4 and Ho will be...

Ganado Europe (A). Using facts in the chapter for Ganado Europe, assume the exchange rate on January 2, 2016, in Exhibit 11.5 dropped in value from $1.1200/ to $0.9300/. Recalculate Ganado Europe's...