Question: The extension spring shown in the figure has full-twisted loop ends. The material is AISI 1065 OQ&T wire. The spring has 84 coils and is

The extension spring shown in the figure has full-twisted loop ends. The material is AISI 1065 OQ&T wire. The spring has 84 coils and is close-wound with a preload of 16 lbf.
(a) Find the closed length of the spring.
(b) Find the torsional stress in the spring corresponding to the preload.
(c) Estimate the spring rate.
(d) What load would cause permanent deformation?
(e) What is the spring deflection corresponding to the load found in partd?

0.162 in L-in R in R

Step by Step Solution

★★★★★

3.38 Rating (170 Votes )

There are 3 Steps involved in it

1 Expert Approved Answer

Step: 1 Unlock

Given N 84 coils F 16 lbf OQT steel OD 15 in d 0162 in DOD d 150162 1338 in a Eq 1039 or b Lo ... View full answer

Question Has Been Solved by an Expert!

Get step-by-step solutions from verified subject matter experts

Step: 2 Unlock

Step: 3 Unlock

Document Format (1 attachment)

233-M-E-M-S (53).docx

120 KBs Word File

Students Have Also Explored These Related Mechanical Engineering Questions!

The beam ABCD shown in the figure has overhangs at each end and carries a uniform load of intensity q. For what ratio b/L will the bending moment at the midpoint of the beam be zero? AB EN

The beam ABCD shown in the figure has overhangs that extend in both directions for a distance of 4.2 m from the supports at B and C, whiich are 1.2 m apart. Draw the shear-force and bending-moment...

The hydraulic cylinder shown in the figure has a 3-in bore and is to operate at a pressure of 800 psi. With the clevis mount shown, the piston rod should be sized as a column with both ends rounded...

Q - 1 3 The extension spring shown in the figure has fulltwisted loop ends. With O D = 3 7 . 5 m m , wire diameter d = 4 m m , r 1 = 1 6 . 7 5 m m , r 2 = 1 2 . 5 m m . The material is AISI 1 0 6 5...

(a) The unpeened extension spring shown in Figure 3 has a wire diameter (d) of 1.1mm, a nominal diameter (D) of 10mm and hook radii of r1=2.9mm and r2=2.3mm. The spring material is cold drawn carbon...

1.A firework leaves the ground with an initial velocity of 45 m/s, travelling vertically upwards. It reaches a maximum height of 100m. At this point the firework fails to explode and falls back down...

Introduction: We can combine springs to get a new spring with different spring constant. Two common ways to combine springs are putting them in series and parallel. In this lab, we will study the new...

Exp number Mass Force, ? = mass* 9.8 m/ 2 Extension ? Spring constant 1 200 g 1.96 N (F = 02 kx x 9.6 = 6/7) 300 g 400 g Percentage error: [(Theoretical value - Experimental value)] *100/(Theoretical...

A within-subjects ANOVA is used when the same participants are observed in __________ conditions. Question 3 options: a) homogeneous b) matched-subjects c) three or more d) independent

I NEED AN ANSWER QUICKLY! I WILL LIKE/UPVOTE! ell The toy maker Mattel makes and sell its popular Jack-in-the-Box toys to little kids and their parents. The extension spring is an important element...

You plan on saving money for retirement in 30 years (t=30) at which time, you wish to have saved $1,000,000. In order to do this, you plan on depositing $10,000 into the bank for 10 years starting...

Which one of the followings is not the characteristics that discourage the use of c. emical potential (4) as a fundamental criterion for phase equilibria. a. Derivation of Mi as fundamental property...

Bonds may be sold: Group of answer choices as shares of equity in a corporation. in the secondary market at a discount or premium. by the federal or state governments only.

Give a brief account of division of labour and job specialization.

The extension spring shown in the figure has full-twisted loop ends. The material is AISI 1065 OQ&T wire. The spring has 84 coils and is close-wound with a preload of 16 lbf. (a) Find the closed...

Design an infinite-life helical coil extension spring with full end loops and generous loop-bend radii for a minimum load of 9 lbf and a maximum load of 18 lbf, with an accompanying stretch of in....

Prove Eq. (1040). Hint: Using Castiglianos theorem, determine the deflection due to bending of an end hook alone as if the hook were fixed at the end connecting it to the body of the spring. Consider...

Lakonishok Equipment has an investment opportunity in Europe. The project costs 15 million and is expected to produce cash flows of 2.8 million in Year 1, 3.4 million in Year 2, and 3.9 million in...

STATISTICS AND PROBABILITY TEST A. The following data show the probabilities for the number of cars sold in a given day at a car dealer store. Number of cars X = 0 | 1 | 2 | 3 | 4 | 5 | 6 | 7 | 8 | 9...

1. Calculate the probability-weighted expected standard deviation for the stock below. State of the Economy Probability Expected Return on Stock Good 0.7 24% Bad 0.2 5% Ugly 0.1 -10% 2. Using the...