Question: Estimate the maximum power in shear spinning a 0.5-in.-thick annealed 304 stainless steel plate that has a diameter of 12 in. on a conical mandrel

Estimate the maximum power in shear spinning a 0.5-in.-thick annealed 304 stainless steel plate that has a diameter of 12 in. on a conical mandrel of a = 30°. The mandrel rotates at 100 rpm and the feed is f = 0.1 in./rev.

Step by Step Solution

★★★★★

3.64 Rating (165 Votes )

There are 3 Steps involved in it

1 Expert Approved Answer

Step: 1 Unlock

The shear spinning process is as shown below Calculate the maximum power as s... View full answer

Question Has Been Solved by an Expert!

Get step-by-step solutions from verified subject matter experts

Step: 2 Unlock

Step: 3 Unlock

Document Format (1 attachment)

972-E-M-E-B-D (651).docx

120 KBs Word File

Students Have Also Explored These Related Mechanical Engineering Questions!

A steam power plant operates on an ideal reheat- regenerative Rankine cycle with one reheater and two feedwater heaters, one open and one closed. Steam enters the high-pressure turbine at 15 MPa and...

A 2.4-L gasoline fuelled internal combustion engine produces a maximum power of 200 hp when the fuel is burned stoichiometrically with air. The thermal efficiency of the engine at this maximum power...

A small stream near a mountain cabin is dammed up to produce a head of 2 m of water at the inlet to a hydroturbine, as sketched in Fig. 4.52. A distance upstream the flow is estimated to be 4 m/s in...

An engineer at a utility company suggests that a hot spring can provide 450 lbm/min to produce power. The average temperature of the spring is 200F, and a 55F stream can be used as a thermal sink....

Please quality check my solutions for this advanced heat transfer problem. Show all work. Thank you. All original documents are located at the bottom. 3.9 COMPACT HEAT EXCHANGERS 3.9.10-1 3.9.10...

DATA CENTERS. WHAT INFO IS NEEDED???/ A. Data Center Conceptual Design Consider the following layout for a data center: Raised floor: cach tile = 24 inches x 24 inches = Z'X2'. Total area: 30' x 14...

A. Data Center Conceptual Design Consider the following layout for a data center: Raised floor: cach tile = 24 inches x 24 inches = Z'X2'. Total area: 30' x 14 Number of cabinets: 5 Each 42Us cabinet...

2. (30 pts) A CATe photovoltaic cell sends a current I to a load with voltage Vacross it. For this 90 cm cell the open circuit voltage is 0.83 V, the short circuit current density is 27 mA/cm and the...

1. The economics of Wind Power: According to a recent article, the average cost of constructing a 1.0 MW land-basedwind power generator is approximately US$1.37M. What is the average cost for energy...

Discussion post questions: link to video: https://youtu.be/ian6NyXpszw (national lampoons Christmas vacation - 250 strands of light uploaded by ghfggrr 1 minutes and 29 seconds long) 1.) In an...

Help with discussion post.Video link: https://youtu.be/ian6NyXpszwThank you. I. In an earlier scene (not shown), Mr. Griswald explains that if one bulb doesn't work, then none of the bulbs in the...

The bending moment for a simply supported beam with a point load at its midpoint is of (A) Hogging type (B) Sagging type (C) Hyperbolic type (D) Trapezoidal type

What was the Haymarket Affair, and why is it important to the history of xenophobia in the U.S.?

Nasdaq is best described as: A . an electronic network of securities dealers. B . an internet broker s market. C . a modern - day trading floor with locations in Chicago and London. D . an electronic...

Case Consider the following hypothesis tests: H0: 20 Ha: <20 The research sample was 50 and the sample mean was 19.4. The standard deviation (standard deviation) is 2. Question: a. Calculate...

Lester entered into a ten-year lease of a floor of a building, with an option to extend for a further three years, on 1 July 20X1. Lease payment are K50,000 per year in advance during the initial...

Nixon Corporation has planned right issue of 50,000,000 Ordinary shares which has par value of PKR 10/- each. The stock of Nixon Corporation is illiquid in nature so therefore, the right issue price...

THINK: Tying is illegal unless the tied product is some thing required to maintain quality, such as in a fran chise for purposes of quality or goodwill. APPLY: Dunkin Donuts is a franchise...

Find I0 in the network shown. 12200v i2 2 Io 2

In the circuit shown, if V0=445° V, find I1 2

Find VS in the network shown if V0=4 -j1 V.

ANSWER A AND B WITH SOLUTIONS: A. Find the value of n and r of the following: If C (n, r) = 1 and P (n, r) = 120 If C (n, r) = 20 and P (n, r) = 120 If C (n, r) = 28 and P (n, r) = 56 If C (n, r) = 3...

1. Your folks just called and would like some advice from you. An insurance agent just called them and offered them the opportunity to purchase an annuity for $17,081.85 that will pay them $2,500 per...

What is the purpose for using the following techniques?: Factorial ANOVA Multiple Linear Regression Linear Regression Exploratory Factor Analysis