9 Problem 6-17 (Algo) 7.14 points Some tasks and the order in which they must be performed according to their assembly requirements are shown in the following table. These are to be combined into workstations to create an assembly line. The assembly line operates 12.5 hours per day. The output requirement is 1,000 units per day. Print PRECEDING TASKS TASK TASK A B C D E F MUW no! A B TIME (SECONDS) 30 10 27 25 18 20 G H I j K L PRECEDING TASKS D E F G H, I J, K TIME (SECONDS) 22 10 12 15 15 14 a. What is the workstation cycle time? Workstation cycle time seconds per unit b. Balance the line using the longest task time rule based on the 1,000-unit forecast, stating which tasks would be done in each workstation. (Leave no cells blank - be certain to enter "O" wherever required.) 9 b. Balance the line using the longest task time rule based on the 1,000-unit forecast, stating which tasks would be done in each workstation. (Leave no cells blank - be certain to enter "O" wherever required.) 7.14 points Work Station Task Idle Time 1 II Print III IV V VI c. What is the efficiency of your line balance? (Round your answer to 1 decimal place.) Efficiency 9 c. What is the efficiency of your line balance? (Round your answer to 1 decimal place.) 7.14 points Efficiency Print d. After production was started, Marketing realized that they understated demand and must increase output to 1100 units. There are two options: reduce cycle time or work overtime. Please identify the following: (Round your answers to the nearest whole number.) cycle time to seconds or work minutes of overtime. 214 points Sluipped e. What is the efficiency of your line balance, assuming It is running at the cycle time determined in part b? (Round your answer to 1 decimal place.) Print Efficiency f. Suppose demand increases by 10 percent. How would you react to this? Assume that you can operate only 8.5 hours per day using regular time. (Round your answer for cycle time down to the nearest whole number. Round your answer for overtime up to the nearest whole number.) cycle time to seconds per unit. Another option is to work minutes overtime