Question: Suppose a batch reactor such as the one in figure has a gas ingredient added to the liquid feed. As long as the reaction is

Suppose a batch reactor such as the one in figure has a gas ingredient added to the liquid feed. As long as the reaction is proceeding normally, the gas is absorbed in the liquid (where it reacts), keeping the pressure low. However, if the reaction slows or the gas feed is greater than can be absorbed, the pressure will start to rise. The pressure rise can be compensated by an increase in liquid feed but this may cause the cooling capacity to beexceeded. Totalizer (FT Target 1- Reactant 1- Totalizar FT Target 2 Reactant 2

Totalizer (FT Target 1- Reactant 1- Totalizar FT Target 2 Reactant 2 Totaliaer Target 3- FT PC Reactant 3HX PT Split-range temperature controler TC -Hot vrater or steam Cooling water

Step by Step Solution

★★★★★

3.21 Rating (159 Votes )

There are 3 Steps involved in it

1 Expert Approved Answer

Step: 1 Unlock

The intention is to run the reactor at the maximum feed rate of the gas to minimize the time cycle b... View full answer

Question Has Been Solved by an Expert!

Get step-by-step solutions from verified subject matter experts

Step: 2 Unlock

Step: 3 Unlock

Document Format (1 attachment)

38-E-C-E-P-C (359).docx

120 KBs Word File

Students Have Also Explored These Related Chemical Engineering Questions!

A chain such as the one in Example 9.2 (with the same parameters) of length b and mass pb is suspended from one end at a point that is a height b above a table so that the free end barely touches the...

Consider a lightbulb circuit such as the one in Figure Q27.1. a. From the simple observations and measurements you can make on this circuit, can you distinguish a current composed of positive charge...

An LC circuit like the one in Figure 32.16 contains an 82.0-mH inductor and a 17.0-F capacitor that initially carries a 180-C charge. The switch is open for t

Determine the bare module, total module, and grassroots cost of the ethylbenzene plant described in Appendix B, Project B.2 B.2. ETHYLBENZENE PRODUCTION, UNIT 300 The majority of ethylbenzene (EB)...

a. Example 13-1: Batch Reactor with an Exothermic Reaction Wolfram 1. Adiabatic Case: Use Wolfram to see whether you can find a trajectory that is ready to ignite and whose trajectory looks like a...

There are too many pages for chapter 3. Here are some pages for it. I think, these are relevant. Q1. Consider the problem described in the table below in which Products A, B, and C are made. The...

Any help at all would be greatly appreciated!!! The pharmaceutical industry is going through a paradigm shift by implementing novel continuous technologies for conducting various organic synthesis....

Republic of Iraq Ministry of Higher Education and Scientific Research University of Technology Chemical Engineering Department MODELING AND SIMULATION OF FCC RISERS A RESEARCH SUBMITTED TO THE...

effective status reports used in project management. b) Discuss challenges and pitfalls for each of the projectstatus reports. c) Explain the difference between the projectstatusreports provided for...

Chapter 5: Hazardous Waste Site Clean-Up Technologies IN THIS CHAPTER Treatment technologies for contaminated hazardous waste sites Containment technologies for contaminated sites Innovative...

Mercantile Bank recently introduced a new bonus plan for its business unit executives. The company believes that current profitability and customer satisfaction levels are equally important to the...

Calculate the conditional formation of FeY - at pH 8.5 in the presence of 1M NaF (given that [F - ]= 1.0M at equilibrium).

Ver what period of time should goodwill be amortized? 4 0 Years Its Useful Economic Life 4 0 Years or its useful economic life, whichever is shorter Goodwill is never amortized

Perform subtraction on the given unsigned binary numbers using the 2s-complement of the subtrahend. Where the result should be negative, find its 2s-complement and affix a minus sign. (a) 10111 -...

(a) Find the 16s-complement of A2B1. (b) Convert A2B1 to binary. (c) Find the 2s-complement of the result in (b). (d) Convert the answer in (c) to hexadecimal and compare with the answer in (a)

Convert decimal numbers 3.25 and 5 to binary. (a) Add the binary numbers obtained, without converting them to decimal. (b) Multiply the binary numbers obtained, without converting them to decimal.

Convert the following numbers - (a) 1000.01011 and (b) 10000.1011 to hexadecimal and decimal. Explain why the decimal answer in (b) is two times that in (a).

List the binary, octal and hexadecimal numbers from (25) 10 to (33) 10 . For at least one of the numbers in each case, show why your answer corresponds to the respective number.

Write chemical equations and equilibrium expressions for the reactions of each of the following weak bases with water. (a) Ammonia, NH 3 , (b) Methylamine, CH 3 NH 2 , (c) Acetate ion, CH 3 COO ,...

For Prob. 57, case (d), estimate the factors of safety from the three theories by graphical measurements of the load line.

Find Vo in the network shown. 1 2H12 mA 1 2 2Vu/1000

Use matlab to find the mesh currents in the network shown. 2mA. 1o 1 2 2 13 6V 1

Use below code as reference / skeleton . Try not to deviate from the windows x 8 6 paradigms. Write a program to ask the user to enter number less than 5 . If the user enters greater than 5 , the...

Choose a stock that interests you. Utilizing Bloomberg, Yahoo Finance, or Google Finance, etc. as a source of data, collect the following information: a. The stock's Beta b. Use the lyr market risk...

The 6-month, 12-month, 18-month, and 24-month zero rates are 3.00%, 3.50%, 4.00%, and 4.50% with semi-annual compounding. Q1: What are the rates with continuous compounding? Q2: What is the forward...