Question: Because the rinse water flow rate for a nickel plating bath is quite high, it is proposed that the countercurrent rinse system shown in Figure

Because the rinse water flow rate for a nickel plating bath is quite high, it is proposed that the countercurrent rinse system shown in Figure P-2-12 be used to reduce the flow rate. Assuming that the C_n concentration remains the same at 28 mg/L, estimate the new flow rate. Assume that the rinse tank is completely mixed and that no reactions take place in the rinse tank.

FIGURE P-2-12

Countercurrent rinse water flow scheme.

Q = 0.05 L/min C = 85 g/A. Q = 0.05 L/min

Q = 0.05 L/min C = 85 g/A. Q = 0.05 L/min C, = 28 mgL. Q = 0.05 L/min Parts Flow Plating Bath Rinse Bath Rinse Bath Rinse Water C =0 Q = ? 85 g/1. Q = ?

Step by Step Solution

★★★★★

3.43 Rating (156 Votes )

There are 3 Steps involved in it

1 Expert Approved Answer

Step: 1 Unlock

Date Qwa lRe can ca ... View full answer

Question Has Been Solved by an Expert!

Get step-by-step solutions from verified subject matter experts

Step: 2 Unlock

Step: 3 Unlock

Students Have Also Explored These Related Accounting Questions!

A unity feedback control system shown in Figure AP7.14 has the process Design a PID controller using Ziegler-Nichols methods. Determine the unit step response and the unit disturbance response. What...

The geared system shown in Figure represents an elevator system. The motor has inertia I and supplies a torque T1. Neglect the inertias of the gears, and assume that the cable does not slip on the...

For the rotational system shown in Figure I = 2 kg.m2 and c = 4 N.m.s/rad. Obtain the transfer function (s)/T(s), and derive the expression for the steady-state speed cos5 (t) if the applied torque...

4 - 1 2 Because the rinse water flow rate for a nickel plating bath ( Problem 4 - 1 1 ) is quite high, it is proposed that the countercurrent rinse system shown in Figure P - 4 - 1 2 be used to...

Republic of Iraq Ministry of Higher Education and Scientific Research University of Technology Chemical Engineering Department MODELING AND SIMULATION OF FCC RISERS A RESEARCH SUBMITTED TO THE...

The Shiny Metal Plating Co. uses the process flow diagram shown below. The plating solution contains 85 g/L of nickel. The parts drag out 0.05 L/min of plating solution into the rinse tank. The flow...

2.1 THE GENERATORS' PRIMARY RESPONSIBILITIES It is solely the generator's responsibility to determine if it generates or manages solid waste, and it is solely the generator's responsibility to...

Two major themes from the introduction to module 4 are "Project Management" and "Managing Risk." Discuss, in depth, your analysis of the company's actions in relation to the concepts of these two...

Chapter 7: Wastewater Management IN THIS CHAPTER U.S. wastewater regulations Sources of contamination of wastewaters Classification of water pollutants Characteristics of wastewater Wastewater...

Due Sunday, 11/20: Problems from Zimmerman text: 2-11, 2-44, Case 2-3, 7-7, and 7-20 Chapter Two The Nature of Costs Chapter Outline A. Opportunity Costs 1. Characteristics of Opportunity Costs 2....

Among the numerous examples of SN1 reactions that occur with incomplete racemization is one reported by Winstein in 1952? The optically pure tosylate of 2, 2-dimethy-1-phenyl-1-propanol ([?] D = ?...

The LAU hotel is composed of 650 rooms as follows: 300 single bed rooms; 300 double bed rooms and 50 suites Average forecasted occupancy percentage per room type is as follows: 65% for single rooms;...

Holmes Corporation files a voluntary pettion with the bankruptcy court in hopes of reorganizing. Company officials prepare a statement of financial affairs showing these debts: \ table [ [...

A 2-kg mixture of 25% N 2 , 50% O 2 , and 25% CO 2 by mass is at 150 kPa and 300 K. Find the mixture gas constant and the total volume.

Write a pseudocode description of a method for finding the smallest and largest numbers in an array of integers and compare that to a Java method that would do the same thing.

Consider a Solow economy that begins in steady state. Then a strong earthquake destroys half the capital stock. Use a Solow diagram to explain how the economy behaves over time. Draw a graph showing...

Review the three scenarios below. Look for which, if any, of these scenarios presents an example of post-investment holdup. 1). Your firm conducted a search for a new chief financial officer and...

Refer to Figure 18.23. Given L 1 = 3 m, L 2 = 6 m, l 1 = 1.5 m, = 16.5 kN/m 3 , sat = 19.0 kN/m 3 , and ' = 35. a. Find the required depth of the sheet pile, increasing the theoretical estimate by...

b. Why might your human inference regarding the cocaine problem among children be misled by the headline on the article? How might you revise it? 2. Was Kobe Streaking? Kobe Bryant's field goal shots...

lab question lab instuction which image because first you said more information and now that the information is provided you said kmavs is not clear. be specific which image isn't clear? Qualitative...

The diagram shown below is a fully automatic laundry machine controller that offers three features - wash, spin and rinse. Water, detergent and softener will be added depending on the user choices....

What approach should Hirsch take with Metropolis? Why? Create a list of 5 risks with the approach you recommend for Hirsch? Take your top 2 risks and discuss how Hirsch could best mitigate each of...

Identify the concepts, indicators, variables, and decision level for those variables Contaminated produce was responsible for the greatest number of foodborne disease outbreaks (696) and illnesses...

Part 1 ) Make a sodium hydroxide solution A student measured 4 . 0 3 grams of NaOH in a tared weigh boat. They then dissolved it into approximately 2 0 0 m L of deionized water in a beaker. Once it...

Design a washing machine controller. Description: The controller begins when it receives the STRT (start) signal from the user. It fills the washer with either cold or hot water (selected by the...